NIPPON PAPER 制纸 SUPERCHLON®1122S
1.Introduction
SUPERCHLON 1122S is a newly developed product specially introduced intoPP primer market,which is specially developed to achieve better storagestability than SUPERCHLON 892LS especially at lower temperature.It isalso suitable for adhesive,ink and paint application for the good adhesion toABS,polyester and nylon as well as polypropylene.
1. 简介
SUPERCHLON 1122S 是专为 PP 底漆市场开发的新产品。相较于 SUPERCHLON 892LS，该产品经过专项开发，低温储存稳定性更为优异。
本品对聚丙烯具备良好附着力，同时对 ABS、聚酯、尼龙基材也有优良的附着效果，同样适用于胶粘剂、油墨以及涂料领域。
2.General properties 基本性能
| 项目 Item | 参数 Specification |
|---|---|
| 外观 Appearance | 淡黄色至浅棕色颗粒 Pale-yellow to light-brown pellet |
| 气味 Odor | 轻微树脂气味 A little resin odor |
| 游离氯 Free chlorine | 无 None |
| 良溶剂 Good solvents | 甲苯、二甲苯（芳香烃）Toluene,Xylene (aromatic hydrocarbons)环己烷、矿油精、甲基环己烷（脂环烃）Cyclohexane,Mineral Spirit,Methylcyclohexane (alicyclic hydrocarbons)脂肪烃（正己烷等）、醇类（异丙醇、丁醇等）、酯类均可作为稀释溶剂Aliphatic hydrocarbons(n-hexane etc.), alcohol (IPA,butanol etc.) and esters can be used as the diluent. |
3.Typical specifications 典型技术指标
| 项目 Item | 指标 Specification |
|---|---|
| 氯含量 Chlorine content (%) | 21.0‑23.0 |
| 粘度 Viscosity (mPa・s at 25℃) | 20‑100（*） |
| 加德纳色度 Color number (Gardner) | 6 号及以下 6 and below |
Solvent:Toluene/Cyclohexane/Isopropyl alcohol=64/33/3
These properties are typical of average lots.Nippon Paper Chemicals makes no representation that the material in any particular shipment will conform to the llsted properties.
Handling Instruction:The solution of this product has a nature to cause viscosity increase, gelling and fine particles in winter season,but in terms of its performance,this will not be a issue if warm up to 40-50 degrees C (104-122 degrees F) again before using
溶剂：甲苯 / 环己烷 / 异丙醇 = 64/33/3
以上性能为多批次产品的典型平均值。日本制纸化学品不保证任意一批次出货产品完全符合上述所列指标。
使用注意事项：本产品溶液在冬季环境下会出现粘度上升、凝胶以及析出细微颗粒的现象；使用前将物料重新加热至 40‑50℃（104‑122℉），产品性能不受影响，可正常使用。